Home > Stone Care
& Restoration >

Aqua Mix KnockDown Honing Powder, 2 Lb.
Aqua Mix KnockDown


 
Price: $72.46

Manufacturer Part #: 100287

Product Code: 30.38250
Qty:

Description
 

Aqua Mix KnockDown Honing Powder

Aqua Mix KnockDown is a non-acidic, honing powder that removes light surface scratches, moderate acid etching, and wear patterns and produces an even, flat, honed finish. It is excellent for safely honing polished marble, limestone, or travertine to a smooth honed surface where a honed, unpolished finish is desired.

Aqua Mix No VOC (Volatile Organic Compound Formulas) help provide better indoor and outdoor air quality compared to similar traditional products.


Uses:

Limestone, marble, and travertine.


Equipment Needed:

  • 1) 175 to 300 RPM floor machine or hand polish machine
  • 2) Natural hair or synthetic fiber tan floor pads
  • 3) KnockDown
  • 4) Protective plastic or blue painter’s tape
  • 5) Spray bottle of water
  • 6) Wet vac
  • 7) Mop and bucket
  • 8) Squeegee

Application:

Test a small area according to application instructions to determine desired results.

1) Read entire label before using.

2) Test in a small inconspicuous area to determine desired results.

3) Sweep or vacuum surface.

4) Protect baseboards, carpet, etc. with protective plastic and/or blue painter’s tape.

5) Surface must be free of existing sealers or coatings.

6) Liberally apply KnockDown to the stone surface.

7) Add water to form a slurry.

8) Refinish using a weighted floor machine fitted with a natural hair or synthetic fiber tan floor pad or use a hand polishing machine. If lippage is present, use two pads, double stacked.

9) Keep slurry wet while buffing. Add KnockDown as needed. Harder stones will require a thicker slurry.

10) Buff area until the desired level of hone has been achieved - squeegee slurry from a small area to check for desired results prior to removing slurry.

11) Rinse well and use a wet vacuum to remove all excess compound.


Limitations:
  • Do not allow product to come in contact with any non-recommended surface.
  • Not intended for use as a pre-polish powder.

Handling & Storage:
  • Close container after each use.
  • Store in original container only.
  • Store and use in temperatures between 50 ºF and 80 ºF (10 ºC and 27 ºC).


CAUTION:

MAY BE HARMFUL IF SWALLOWED. MAY IRRITATE EYES AND SKIN. Wear skin and eye protection. Contains non-reactive mineral powders. If in eyes, flush with water for at least 15 minutes. If on skin, wash with soap and water. If irritation persists, seek medical attention. If swallowed, DO NOT induce vomiting. Seek medical attention.

KEEP OUT OF REACH OF CHILDREN

Limited Product Warranty Custom Building Products (“Custom”) warrants to the original consumer purchaser that its product shall be free from defects in material and workmanship under normal and proper usage for a period of one year following the date of original purchase. Custom’s sole liability under this warranty shall be limited to the replacement of the product. Some states, countries or territories do not allow the exclusion or limitation of incidental or consequential damages, so the above limitation or exclusion may not apply to you. This warranty will not extend to any product which has been modified in any way or which has not been used in accordance with Custom’s printed instructions. Custom makes no other warranties either expressed or implied. This warranty gives you specific legal rights, and you may have other rights that vary from state to state or from one country/territory to another.

Coverage:

Approximately 100 to 200 sq. ft. (10 m2 to 18 m2) per pound (.45 kg) depending on the hardness of the stone and method of application. Container size: 2 Lbs.

Share your knowledge of this product with other customers... Be the first to write a review

Browse for more products in the same category as this item:

Stone Care
& Restoration
Stone Care
& Restoration > Restoration
Home > Aqua Mix
Brands > Aqua Mix
Brands > Aqua Mix > Problem Solvers
Home > KnockDown
Stone Care
& Restoration > Floor Restoration
Stone Care
& Restoration > Floor Restoration > Chemicals, Compounds & Powders
Brands
Home